|本期目录/Table of Contents|

[1]徐军,唐甲,杨薇.锶掺杂二钛酸钡的熔盐法制备及其介电性能[J].武汉工程大学学报,2013,(06):40-43.[doi:103969/jissn16742869201309008]
　XU Jun,TANG Jia,YANG Wei.Synthesis of strontiumdoped barium dititanate and its dielectricproperties by molten salt method[J].Journal of Wuhan Institute of Technology,2013,(06):40-43.[doi:103969/jissn16742869201309008]
点击复制

锶掺杂二钛酸钡的熔盐法制备及其介电性能(/HTML)
分享到：

《武汉工程大学学报》[ISSN:1674-2869/CN:42-1779/TQ]

卷:
期数:
2013年06期
页码:
40-43
栏目:
资源与土木工程
出版日期:
2013-06-30

文章信息/Info

Title:
Synthesis of strontiumdoped barium dititanate and its dielectricproperties by molten salt method
文章编号:
16742869(2013)06004004
作者:
徐军; 唐甲; 杨薇
武汉工程大学材料科学与工程学院，湖北 武汉 430074
Author(s):
XU Jun;  TANG Jia;  YANG Wei
School of Materials Science and Engineering, Wuhan Institute of Technology, Wuhan 430074,China
关键词:
二钛酸钡; 熔盐法; 锶替代; 织构化陶瓷; 介电性能
Keywords:
barium dititanate;  molten salt synthesis;  strontium substitution;  textured ceramic;  dielectric properties
分类号:
TM282
DOI:
103969/jissn16742869201309008
文献标志码:
A
摘要:
为了获得织构化的二钛酸钡陶瓷，并利用元素替代调控和改善陶瓷介电性能的特点，采用熔盐法，以碳酸钡，二氧化钛和碳酸锶为原料，以氯化钠和氯化钾为熔盐，在840 ℃反应5 h，X射线衍射结果显示，得到的粉体为单相，说明锶离子完全进入了二钛酸钡晶格，成功制备出了摩尔比为1%锶掺杂的二钛酸钡粉体.通过扫描电子显微镜形貌分析显示，制备的二钛酸钡锶单晶颗粒呈棒状，长约2.0 μm，矩形截面宽约为100～200 nm.棒状颗粒所组成的粉体经单轴压力压片、烧结后得到的二钛酸钡锶陶瓷，居里温度约为415 ℃，说明当锶掺杂量为1%（摩尔比）时，相比未掺杂的单晶二钛酸钡的居里温度略有降低.在测量频率为10 kHz～10 MHz的范围内，陶瓷片在成型时压力轴垂直方向上的介电常数峰值约是平行方向上介电常数峰值的3倍，说明陶瓷的介电性能具有明显的各向异性，成功获得了织构化的二钛酸钡锶陶瓷.
Abstract:
To obtain textured barium dititanate ceramics and tailor the dielectric properties, 1%（mole ratio） strontiumdoped barium dititanate powders were successfully synthesized at 840 ℃ for 5 hours by molten salt method, with barium carbonate, strontium carbonate and titanium dioxide as precursors, sodium chloride and potassium chloride as mixed salts. The Xray diffraction shows that the products are in single phase, indicating that the strontium ions entered the lattice of barium dititanate. Morphology analysis by scanning electron microscopy shows that the obtained single crystal particles are rodshaped with a rectangular cross section, up to 2.0 μm in length and about 100-200 nm in width. After the particles being pressed with an uniaxial pressure into pellets and sintered subsequently, textured ceramics were successfully fabricated, they show significant anisotropic dielectric properties with the ferroelectric Curie temperature about 415 ℃,which is a little lower than that of nondoped barium dititanate. At differernt frequencies ranging from 10 kHz to 10 MHz, the maximum dielectric constant measured in the direction perpendicular to the forming pressure is three times larger than in the parallel direction.

参考文献/References:

［1］Akishige Y,Fukano K, Shigematsu H.New ferroelectric BaTi2O5\[J\]. Jpn J Appl Phys,2003,42(8):946948.［2］Na Zhu,Anthony R West.Formation and Stability of Ferroelectric BaTi2O5\[J\]. Am Ceram Soc,2010,93(1):295300.［3］Lee S,Randall C A,Liu Z K. Modified phase diagram for the barium oxidetitanium dioxide system for the ferroelectric barium titanate\[J\]. Am Ceram Soc，2007,90(8):25892594.［4］Héctor Beltrán,Beatriz Gómez,Nahum Masó,et al.Electrical properties of ferroelectric BaTi2O5 and dielectric Ba6Ti17O40 ceramics\[J\].Appl Phys,2005,97(8):084104(16).［5］Yao Zhonghua, Liu Hanxing, Liu Yan, et al.Structure and Dielectric Behavior of NdDoped BaTiO3 Perovskites Materials\[J\].Chem and Phy,2008,109(2):475481.［6］Ray S,Mahadevan P,Mandal S,et al.High temperature ferromagnetism in single crystalline dilute Fedoped BaTiO3\[J\].Phys Rev B,2008,77(10):11031109.［7］岳新艳，茹红强，涂溶，等.Mg掺杂对二钛酸钡(BaTi2O5)的介电性能的影响\[J\].材料与冶金学报,2009,8(3):202204. Yue Xinyan,Ru Hongqiang,Tu Rong,et al. Effect of MgO on dielectric properties of polycrystalline BaTi2O5 prepared by arc melting\[J\].Journal Materials and Metallurg,2009,8(3):202204.（in Chinese）［8］Jun Xu,Yukikuni Akishige.Relaxor in KFdoped BaTi2O5 ceramics by spark plasma sintering\[J\].Appl Phys Lett,2008,92(5):052902(13).［9］Jun Xu,Yukikuni Akishige.KFdoped BaTi2O5 ferroelectric ceramics by solidstate reaction of KF and solgelderived BaTi2O5 powders\[J\].Materials Science&Processing. Appl Phys A,2008,90(6):153157.［10］徐军,冷浩博,伍建华.二维片状二钛酸钡颗粒的熔盐法合成\[J\].武汉工程大学学报,2012,34(7):3740.Xu Jun,Leng Haobo,Wu Jianhua.Synthesis of 2D platelike barium dititanate particle by molten salt method\[J\].Journal of Wuhan Institute of Technology, 2012,34(7):3740. （in Chinese）

相似文献/References:

[1]徐军,张立果,贺晓平.助熔剂法生长二钛酸钡单晶[J].武汉工程大学学报,2012,(06):53.[doi:103969/jissn16742869201206013]
　XU Jun,ZHANG Li\|guo,HE Xiao\|ping.Growth of barium dititanium single crystals by flux method[J].Journal of Wuhan Institute of Technology,2012,(06):53.[doi:103969/jissn16742869201206013]
[2]徐军,伍建华,胡承威.片状钛酸钡颗粒的熔盐法制备及其形貌[J].武汉工程大学学报,2013,(07):49.[doi:103969/jissn16742869201307010]
　XU Jun,WU Jian hua,HU Cheng wei.Moltensalt synthesis and morphology of platelike barium titanate particles[J].Journal of Wuhan Institute of Technology,2013,(06):49.[doi:103969/jissn16742869201307010]
[3]徐军,周淼,赵焕校.铁微量掺杂对二钛酸钡陶瓷介电性能的影响[J].武汉工程大学学报,2014,(05):25.[doi:103969/jissn16742869201405006]
　XU Jun,ZHOU Miao,ZHAO Huan xiao.Influence of lightdoped Fe on dielectric properties of barium dititantate ceramics[J].Journal of Wuhan Institute of Technology,2014,(06):25.[doi:103969/jissn16742869201405006]
[4]徐军,冷浩博,伍建华.二维片状二钛酸钡颗粒的熔盐法合成[J].武汉工程大学学报,2012,(7):37.[doi:103969/jissn16742869201207008]
　XU Jun,LENG Hao bo,WU Jian hua.Synthesis of 2D platelike barium dititanate particle by molten salt method[J].Journal of Wuhan Institute of Technology,2012,(06):37.[doi:103969/jissn16742869201207008]

备注/Memo

备注/Memo:
收稿日期：20130420基金项目：教育部留学回国人员科研启动基金，湖北省教育厅科学研究重点项目（D20101504）作者简介：徐军(1970)，男，湖北武汉人，博士，教授.研究方向：电子功能材料.
更新日期/Last Update: 2013-07-11